一、產品簡介
I Product Introduction
FB-201 清潔劑乃是針對細線路、小孔徑之高密度配線板所開發之硫酸型酸性清潔劑，使用特殊之界面活性劑，水洗性良好,具有良好之清潔力，不攻擊電路板的防焊油墨及影像干膜，可強力去除銅面氧化，對銅線路表面具有清潔及活化作用。
FB-201 cleaner is a acid cleaner designed for the high-density circuit with thin line and small hole, and it uses special interface activator, has good washing ability and cleaning ability; it will not attack the solder mask and image dry film of circuit board, can remove oxide on copper surface, and has cleaning and activation function on surface of copper line.
二、配槽方法
II Makeup Method
建浴標準 :
1. Makeup Standard
1L槽液
1L solution |
主要作用
Main Function |
體積（ml）
Volume |
純水
Pure water |
溶劑
Solvent |
900ml |
| FB-201 |
清潔
Cleaning |
100ml |
操作條件 :
2. Operating Condition
組份/參數
Component/Parameter |
最佳值/工作范圍/要求
Optimal value/Work Scope/Requirement |
濃 度
Concentration |
10% |
溫 度
Temperature |
45 ℃ (40-50 ℃) |
時 間
Time |
5 分鐘(4-6 分鐘)
5 minutes (4-6 minutes) |
槽 材 質
Material of bath |
使用 PVC 或 P.P 材質之槽材質
Use PVC or PP as the bath material |
加 熱 器
Heater |
石英 鐵氟龍
Quartz, Teflon, |
過 濾
Filter |
10-20 μm PP濾心，3-4 turn-over/hr
10-20 μm PP filter element, 3-4 turn-over/hr |
攪 拌
Mixing |
過濾循環
Filter circulation |
水 洗
Water washing |
2 段水洗
Two sections of water washing |
槽液維護 :
Maintenance of solution
1) 固定添加：
1) Fixed adding
處理 1 m 2 需添加 FB-201 約 20 ml
Add about 20ml FB-201 for processing 1 m 2;
2) 分析校正：
2) Analysis and calibration
依照 “ 酸性清潔劑 FB-201 分析方法 “ 分析校正
Make analysis and calibration according to “Analysis method of acid cleaner FB-201”
3) 換槽標準：
3) Bath replacing standard
2 turn-over 換槽
2 turn-over: replace bath
三、產品性狀
III Product Property
品名
Product name |
外觀
Appearance |
比重
Specific gravity |
PH 值
PH Value |
閃火點
Flash point |
| FB-201 |
無色透明液體
Colorless transparent liquid |
1.05±0.05 |
< 1 |
不可燃
Non- combustible |
四、注意事項
IV Notes
1、酸性清潔劑 FB-201 是酸性腐蝕性液體，請避免身體直接接觸，請小心使用。
1. Acid cleaner FB-201 is acid corrosive liquid, please avoid direct contact with body and use it carefully;
2、使用時請佩戴手套、安全眼鏡，萬一藥液沾到眼睛時，請以清水沖洗 15 分鍾以上，并至眼科診所診治。
2. When using it, Please wear gloves and eyeshade; in case of spattering into eye, immediately flush with clean water for over 15 minutes and get medical treatment;
3、產品儲存請放置陰涼處，并防止日曬，以防止產品變質。
3. The product shall be stored in cool place, being away from sunshine; |
